Tell us about the job
Takes about a minute. No obligation.
Sizing a furnace for Posey County starts with what the climate actually demands of the equipment, not with what the catalog suggests for a square footage. 92 severe weather events were recorded in Posey County, Indiana between 2015 and 2024. At that rate, severe weather is a standing condition here, not an occasional disruption, and a contractor has to account for that before settling on equipment spec or duct design. A unit undersized for real load cycles harder, wears faster, and loses efficiency well before its time. Getting the install right the first time means the equipment runs against this climate on its own terms.
Ductwork laid down when much of this county's housing was new was sized and routed for systems that bore little resemblance to what a contractor installs today. Half the homes in Posey County, Indiana were built in 1976 or earlier (2020-2024 ACS 5-year). That gap is what a contractor has to account for before a new furnace goes in: whether the existing trunk lines and branch runs will actually carry the airflow a modern unit delivers, and whether the electrical service at the panel is what the new equipment requires. If either falls short, the installation scope changes before the furnace itself is ever touched.
What Gets Installed With a New Furnace
The furnace itself sits in a utility space, a basement, or a closet near the center of the house. It is the unit that produces heat by burning fuel or running electrical elements through a heat exchanger. The blower inside the cabinet then pushes that warmed air out through the supply side of the system.
The flue pipe runs from the furnace cabinet to an exterior wall or up through the roof, carrying combustion gases out of the house. Alongside the furnace, a contractor also installs the thermostat on an interior wall, which serves as the control point for the whole system.
The drawing shows a typical layout, and a licensed contractor determines what applies to this particular house.
Find a contractor in Posey CountyPosey County, by the numbers
92 severe weather events were recorded in Posey County, Indiana between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Posey County, Indiana were built in 1976 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesPosey County, Indiana holds 11,105 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 82.3% of the occupied homes in Posey County, Indiana (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesCodes & Standards for Furnace Installation in Posey County, Indiana4 sourced rules and standards
What the Installation Actually Looks Like
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Severe Weather Events in Posey County
Posey County's weather puts real demands on heating equipment, and those demands vary from year to year. How hard a furnace has to work over its lifetime is a local question, and local conditions are what contractors here size and install for.
92 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.